防腐木在現在的戶外建筑中的應用越來越廣泛，下面濟南防腐木廠家給大家介紹一下防腐木的制作與安裝注意事項及后期養護，希望對大家有所幫助！
Antiseptic wood is more and more widely used in outdoor buildings. Now Jinan Antiseptic Wood Factory will introduce to you the matters needing attention in the manufacture and installation of antiseptic wood and its later maintenance, hoping to help you!
1、防腐木地板施工前準備
1. Preparations for construction of anticorrosive wood flooring
將施工現場清理干凈，地面施工質量達到設計要求，做好防水，隔潮和隔氣處理；將需要安裝的地面螺絲和鍍鋅角碼固定龍骨，不銹鋼十字螺絲在防腐木的正面與龍骨鏈接鋪設；戶外木材應在戶外陰干與外界環境的濕度大體相同的程度在施工。使用含水量很大的木材施工安裝后會出現較大的變形和開裂。
Clean up the construction site, the construction quality of the ground meets the design requirements, do a good job of waterproofing, moisture insulation and air insulation treatment; will need to install ground screw and galvanized corner code fixed keel, stainless steel cross screw in the front of the anti-corrosion wood and keel link laying; outdoor wood should be in the same degree of humidity with the outside environment in the construction. Large deformation and cracking will occur after construction and installation of wood with large water content.
2、防腐木地板施工現場找平
2. Leveling of Anticorrosive Wood Flooring Construction Site
龍骨在地面找平，地表面無浮土、明顯突出和施工廢棄物，可以用儀器檢測地面平整度。地面找平，用龍骨鏈接成框架或者井字結構，鋪設防腐木。在施工現場，防腐木材應通風存放，應盡可能的避免太陽暴曬。
The keel is leveled on the ground. There is no floating soil on the surface, and there are obvious outbursts and construction waste. The leveling of the ground can be measured by instruments. Floor leveling, with keel links into a frame or well-shaped structure, laying anti-corrosion wood. In the construction site, the preservative wood should be stored by ventilation, and the sun exposure should be avoided as far as possible.
3、 木結構基層的處理
3. Treatment of Wood Structure Base
設計施工中應充分保持防腐木材與地面之間的空氣流通，可以更有效延長木結構基層的壽命。
In the design and construction, the air flow between the anti-corrosive wood and the ground should be fully maintained so as to prolong the service life of the base of wood structure more effectively.
4、防腐木安裝
4. Installation of anticorrosive wood
制作安裝防腐木時，防腐木之間需留0.2-1cm的縫隙（根據木材的含水量再決定縫隙的大小，木材含水量超過30%時不應超過0.8cm為好）可避免雨天積水及防腐木的膨脹；厚度大于50mm或者大于90mm的方柱為減少開裂可在背面中心位置開一道槽；在搭建露臺時盡量使用長木板減少接頭，以求美觀；木龍骨一定要防腐，相鄰龍谷間距與平臺板厚成正比，但大不超過1米為宜。
When making and installing anticorrosive wood, the gap between the anticorrosive wood should be 0.2-1 cm (the size of the gap should be determined according to the moisture content of the wood, when the moisture content of the wood exceeds 30%, it should not exceed 0.8 cm) to avoid water accumulation in rainy days and the expansion of the anticorrosive wood; the square column with thickness greater than 50 mm or more than 90 mm can be grooved in the center of the back in order to reduce the cracking; the long wood should be used as far as possible when building the balcony. The plate reduces the joints in order to be beautiful; the wooden keel must be anticorrosive, and the distance between adjacent valleys is proportional to the thickness of the platform plate, but the maximum is not more than 1 meter.
5、防腐木五金件的應用
5. Application of Anticorrosive Wood Hardware
平臺板與木龍骨連接，每塊板與龍骨接觸時需要用兩顆釘；五金件應用不銹鋼、熱鍍鋅或銅質的（主要避免日后生銹腐蝕，并影響連接牢度）連接安裝時請預先鉆孔，以避免防腐木開裂；安裝固定龍骨在基礎必須打水平，保證安裝后整個平臺水平面高度一致。
Platform board is connected with wooden keel, two nails are needed when each board contacts with keel; when hardware is connected and installed with stainless steel, hot-dip galvanized or copper (mainly to avoid rusting and corrosion in the future and to affect the connection fastness), drill in advance to avoid cracking of anticorrosive wood; when installing and fixing keel, the level of the foundation must be made to ensure that the whole horizontal plane of the platform is highly consistent after installation.
6、防腐木涂料、砂光
6. Antiseptic Wood Coatings and Sanding
在施工現場，應盡可能使用防腐木材現有尺寸。如需現場加工，應使用相應的防腐劑充分涂刷所有切口及孔洞，以保證防腐木材的使用壽命。如遇陰雨天，好避免施工。
In the construction site, the existing size of preservative wood should be used as far as possible. If on-site processing is required, the corresponding preservatives should be used to fully coat all incisions and holes to ensure the service life of preserved wood. In case of cloudy and rainy days, it is best to avoid construction.
7、防腐木完工后的維護
7. Maintenance of anticorrosive wood after completion
安裝完成后，為了保護板面清潔美觀，宜用木油（有透明和有色之分）涂刷表面，而不能按照常規油漆涂刷。木油可以在木器表面加上一層保護膜，使其可以達到防水，防起泡，防起皮和防紫外線的作用；防腐木表面用戶外防護涂料或油基類涂料涂刷完后，為了達到佳效果，48小時內避免人員走動或重物移動，以免破壞防腐木面層已形成的保護膜。如想取得更優異的防臟效果，必要時面層在做兩道專用戶外清漆處理。
After installation, in order to protect the board surface clean and beautiful, it is advisable to use wood oil (transparent and colored) to paint the surface, but not in accordance with the conventional paint. Wood oil can be added a protective film on the surface of wood to make it waterproof, anti-foaming, anti-skinning and anti-ultraviolet. After the user's external protective coatings or oil-based coatings have been painted on the surface of wood, in order to achieve the best effect, people should avoid moving or moving heavy objects within 48 hours to avoid damaging the protective film formed on the surface of wood. If you want to achieve better anti-fouling effect, if necessary, the surface layer is treated with two special outdoor varnishes.
戶外使用出現裂紋、細微變形、屬正?，F象，并不影響其防裂性能和結構強度。
Cracks, slight deformations and normal phenomena occur in outdoor use, which do not affect the crack prevention performance and structural strength.
8、及時清潔定期打蠟
8. Clean in time and wax regularly
防腐木表面清潔可用一般洗滌劑來清洗，工具可用刷子；在后期使用中，需要定期，一般間隔一年到半年的時間，用木蠟油對防腐木表面做好保護處理，來增強其表面的防水防污性能。
Antiseptic wood surface cleaning can be done with general detergents, tools can be used with brushes; in the later use, it is necessary to regularly interval between one year and half a year, use wood wax oil to protect the surface of antiseptic wood, to enhance its waterproof and antifouling performance.
This is the content of pure dry goods introduced to you by Jinan Antiseptic Wood Manufacturer Xiaobian today. I believe that today's content can bring you some help. If you still don't understand the content of this article, you are welcome to click on our official website to discuss: http://www.missoularedtape.com.
傳真：0531-86370030
